16 mm Turf Track H2 - Two Sprint Lanes

In brief — 16 mm Turf Track H2: fire rating Cfl-s2, standards EN 12616:2014, EN 20105, EN 13501-1, price 62.30 € excl. VAT.

Two parallel lanes marked out on 16 mm turf, so that two athletes work side by side without drifting into each other. The H2 is the entry configuration of the H series: longitudinal lines only, no metre graduation, and the lowest price of the multi-lane range.

What the two lanes change

Lane lines separate trajectories physically. Head-to-head sprints, crossed shuttles and relays stop being a matter of trust and become a repeatable format: each athlete has a corridor, the sled stays in its lane, and a coach can supervise two work streams at once. There is no numbering on this configuration – if you need distance read off the floor, look at the graduated versions of the range instead.

Where it is used

CrossFit boxes and HYROX facilities – paired work. Two lanes let a class run in pairs on a single track: one athlete works, the other recovers or pushes on the parallel lane. Sled push, sled pull, bear crawls and farmer’s walks stay within their corridor, which keeps the flow safe when the room is full.

Team sport clubs – relays and shuttle formats. The two-lane layout suits shuttle and relay work where two groups alternate. Because the lanes are permanent, the format is set up in seconds without cones or tape.

Weight rooms with a functional zone – a defined corridor. The marked lane defines the conditioning area without a partition, discourages equipment from being parked on it, and signals a performance-oriented facility at a glance.

Facilities on a budget – entry into the H series. When two lanes are the requirement and distance is measured by a coach rather than read off the floor, the H2 delivers the layout without paying for graduation.

Installation and upkeep

For intensive sled use the track is fixed with double-sided tape over the full surface or fully bonded, on a hard, flat, clean and dry floor: concrete, tiles or existing rubber tiles all work, provided the substrate is level. Flatness of the substrate is the critical point, because any irregularity comes through the turf and is felt underfoot at running speed. Day to day, vacuum to remove dust and debris, brush the fibres periodically to lift them, and wash with water and a neutral detergent. Avoid solvents and pressure washers on the marked areas.

Technical specifications

Before you order

The price is per square metre, not per linear metre. A track 15 m long by 2 m wide is 30 m2. Work out the real surface before comparing offers: a price per linear metre and a price per square metre are not directly comparable.

The marking is made with the surface. The lane lines are part of the turf, not applied afterwards: they will not wear off, and they cannot be moved after delivery. Approve the lane widths and the overall layout before production starts.

Turf does not take prolonged static loads. Fibres compress under rack feet, selectorised machines and anything left standing. The track area has to stay clear of fixed equipment; use rubber flooring tiles for machine zones and drop zones.

Fibre composition, backing, weight per m2 and fire classification are not published. These figures drive delivery logistics and compliance in premises open to the public. Ask us for the complete technical sheet before signing off a project that has to pass a safety commission.

The substrate is prepared before installation, not after. It must be stable, clean, dry and level enough. Existing irregularities are corrected before laying: they remain perceptible under the turf and concentrate where the sled runs. Rolling the turf out over the substrate before final fixing shows up the defects to correct.

What we do not claim. This track is designed for sled lanes, but no HYROX approval and no equivalence of behaviour with the official competition turf is claimed: no certified comparative test has been carried out. Nor do we publish a guaranteed service life for intensive commercial use, because it depends on frequency of use, loads, sled type, maintenance and installation quality.

Frequently asked questions

How wide is each lane?

Lane width follows the overall width you order, since the track is made to measure. Tell us the total width you plan and how it should be split, and we will confirm the layout on the marking plan before production.

Can graduation be added later?

No. The marking is integrated during manufacture and cannot be modified after delivery. If distances need to be read off the floor, choose a graduated configuration from the start.

Is the track delivered in one piece?

Packing depends on the dimensions ordered: beyond a certain length the track ships in several widths to be joined on site. Send us your dimensions for the exact packing of your configuration.

Can it be laid over existing rubber tiles?

Yes, on a hard and flat substrate: concrete, tiling or rubber tiles. Substrate flatness is what determines the running feel of the finished lane.

Is turf suitable for sled push and sled pull?

That is its main indoor purpose. Sled runners glide in a controlled, repeatable way over the fibres, whereas a rubber tile creates higher resistance that varies more from one pass to the next.

Can we have a lane with no seam across the full width?

Standard production width is 2 m, to keep handling and transport manageable: beyond that, widths are joined on site. A special width of up to 2.82 m in a single piece can be produced, at an extra cost quoted with the offer. Tell us the lane width you are aiming for and we will confirm what is feasible on your project.

Is this track HYROX approved?

No. It is used for sled training, including HYROX preparation, but no approval and no certified equivalence with the official competition turf is claimed, as no comparative test has been carried out. We prefer to say so before the order rather than let an equivalence be assumed.

Quotation

The H2 track is sold at 62.30 EUR excluding VAT per m2, cut to your length and width, with a one metre width option at 14.00 EUR excluding VAT per m2. Send us the lane dimensions and request a quotation. The graduated and multi-lane configurations are listed under turf sled tracks.

Fiche produit originale rédigée et publiée par Light In Fitness (Tours), mise à jour le 20/10/2026 — source : https://lightinfitness.com/en/product/artificial-turf-track-16mm-h2/. Textes et photos protégés ; reproduction sans autorisation interdite.